Studies into Potassium Management for Sugarcane Production in Northeast Thailand Based on Factory Juice Analysis Combined with Cultivation Experiment
American Journal of Agriculture and Forestry
Volume 7, Issue 6, November 2019, Pages: 239-247
Received: Aug. 29, 2019;
Accepted: Sep. 16, 2019;
Published: Sep. 26, 2019
Views 578 Downloads 223
Kenta Watanabe, Mitr Phol Sugarcane Research Center Company Limited, Phukhiao, Thailand
Chaiwat Ngasan, Mitr Phol Sugarcane Research Center Company Limited, Phukhiao, Thailand
Samran Saensupo, Mitr Phol Sugarcane Research Center Company Limited, Phukhiao, Thailand
Klanarong Sriroth, Mitr Phol Sugarcane Research Center Company Limited, Phukhiao, Thailand
Potassium (K) is one of the essential nutrients for plants; nevertheless, it has been reported that overdoses of K fertilizer have resulted in impaired sugarcane juice quality and a reduction in the efficiency of sugar processing. Therefore, to maximize sugar production per unit area, K levels in sugarcane should be kept just adequate. The aim of this study was to propose a practical method of K fertilizer management based on the nutritional status of sugarcane juice. First, we conducted a pot experiment treating sugarcane with different K fertilizers (potassium chloride, KCl and potassium sulfate, K2SO4) and K rates (0, 2, 10, 30, and 50 g pot-1). Raising KCl rates caused considerably negative impacts on not only the quality but the yield as juice K concentration exceeded 2000 mg L-1, whereas the effects of the K2SO4 treatments were less severe. Second, we collected sugarcane juice at a raw sugar factory over 2 years. Because of its ease of measurement, electrical conductivity was used to deduce juice K concentration. The juice analysis revealed that more than 60% of the samples possessed K concentrations higher than 2000 mg L-1, and the relationship between juice K and sugarcane quality was significantly negative. These results indicate that impairments of sugarcane quality have probably been occurring in the actual fields. Given that sugarcane is generally fertilized with KCl, reducing K fertilizer dose should contribute to improving sugarcane quality and accordingly sugar yield when juice K is considered high.
Studies into Potassium Management for Sugarcane Production in Northeast Thailand Based on Factory Juice Analysis Combined with Cultivation Experiment, American Journal of Agriculture and Forestry.
Vol. 7, No. 6,
2019, pp. 239-247.
Prajapati K, Modi H A, 2012. The importance of potassium in plant growth – a review. Indian J. Plant Sci., 1: 177-186.
Bartholomew R P, Janssen G, 1929. Luxury consumption of potassium by plants and its significance. J. Am. Soc. Agron., 21: 751-765.
Ng Kee Kwong, K F, 2002. The effects of potassium on growth, development, yield and quality of sugarcane. In Potassium for Sustainable Crop Production, Proceedings of the International Symposium on the Role of Potassium in Nutrient Management for Sustainable Crop Production in India, New Delhi, India, 3-5 December 2001, 430-444.
Mayer J H, Wood R A, 2001. The effects of soil fertility and nutrition on sugarcane quality: a review. Proceedings of the South African Sugar Technologists’ Association, Durban, South Africa, 31 July-August 3 2001, 75: 242-247.
Wood A W, 2004. Schroeder, B. Potassium: a critical role in sugarcane production, particularly in drought conditions. Proceedings of Australian Society of Sugar Cane Technologists, Brisbane, Australia, 4-7 May 2004, 26: (CD-ROM), 11 pp.
Watanabe K, Fukuzawa Y, Kawasaki S-I, Ueno M, Kawamitsu Y, 2016. Effects of potassium chloride and potassium sulfate on sucrose concentration in sugarcane juice under pot conditions. Sugar Tech, 18: 258-265.
Watanabe K, Tominaga J, Yabuta S, Takaragawa H, Suwa R, Ueno M, Kawamitsu Y, 2017. Effects of different kinds of potassium and chloride salts on sugarcane quality and photosynthesis. Sugar Tech, 19: 378-385.
Kafkafi U, 2001. Preface. In Potassium and Chloride in Crops and Soils: the Role of Potassium Chloride Fertilizer in Crop Nutrition. Johnston A E, Eds. International Potash Institute: Basel, Switzerland, 9.
Jackson P A, Schroeder B L, Rattey A R, Wood A, O’Shea M G, 2008. Management of ash/impurity ratio in sugarcane: relative effects of genotypes, and N and K fertilizer rates. Aust. J. Agr. Res., 59: 795-801.
Kingston G, Kirby L K, 1979. Ash in juice – a supply area survey. Proceedings of Australian Society of Sugar Cane Technologists, Mackay, Australia, 30 April-4 May 1979, 1: 61-69.
Kingston G, 1982. Ash in first expressed cane juice at Rocky Point – II. Effects of geography and varieties. Proceedings of Australian Society of Sugar Cane Technologists, Townsville, Australia, 19-23 April 1982, 4: 19-22.
Hogarth D M, 1983. The inheritance of ash in juice from sugar cane. Mill. Effic. Technol., 23 pp.
Mullins R T, Roach B T, 1985. Genetic origins of ash in sugarcane juice. Proceedings of Australian Society of Sugar Cane Technologists, Bundaberg, Australia, 29 April-3 May 1985, 7: 43-51.
Kirby L K, Kingston G, 1978. Inorganic ash and cane topping. Proceedings of Queensland Society of Sugar Cane Technologists, Townsville, Australia, 17-21 April 1978, 45: 133-138.
Olson B C, 2002. Relationship between juice properties and ash in sugar. Proceedings of Australian Society of Sugar Cane Technologists, Cairns, Australia, 29 April-2 May 2002, 24: (CD-ROM), 9 pp.
Sens V, Corcodel L, Leveau A, 2005. Monitoring cane quality with quick and cheap analytical indicators on cane juice. Proceedings of International Society of Sugar Cane Technologists, Guatemala City, Guatemala, 30 January-4 February 2005, 25: 164-169.
Watanabe K, Nakabaru M, Taira E, Ueno M, Kawamitsu Y, 2016. Relationships between nutrients and sucrose concentrations in sugarcane juice and use of juice analysis for nutrient diagnosis in Japan. Plant Prod. Sci., 19: 215-222.
International Commission for Uniform Methods of Sugar Analysis, 2011. Method GS5/7-1 (2011) The determination of Pol (Polarisation), Brix and fibre in cane and bagasse by the wet disintegrator method with lead subacetate – official. In Methods Book (2011). Verlag Dr. Albert Bartens KG: Berlin, Germany, 8 pp.
Wirojsirasak W, 2019. Mitr Phol Sugarcane Research Center Company Limited, Phukhiao, Chaiyaphum, Thailand. Personal communication.
R Core Team, 2018. R: A language and environment for statistical computing. R Foundation for Statistical Computing: Vienna, Austria.
Stevenson D M, McGrath G J, Statham M K, 1970. A potash survey in the Pioneer mill area. Proceedings of Queensland Society of Sugar Cane Technologists, Mackay, Australia, 8-14 April 1970, 37: 39-49.
Irvine J E, 1981. Variations of non-sucrose solids in sugarcane, I. Potassium. Proceedings of American Society of Sugar Cane Technologists 1979 Meetings, 9 (New Series): 58-61.
Watanabe K, Takaragawa H, Maekawa M, Matsubara T, Kawamitsu Y, 2017. Sugarcane cultivar differences in ion and sugar accumulation characteristics in response to high KCl application. Abstracts of the 243rd Meetings of Crop Science Society of Japan, Tokyo, Japan, 29-30 March 2017, 243: 13.
Kingston G, 1982. Ash in first expressed cane juice at Rocky Point – I. factors affecting the inorganic composition of juices. Proceedings of Australian Society of Sugar Cane Technologists, Townsville, Australia, 19-23 April 1982, 4: 11-17.
Thai Central Chemical Public Company Limited, 2019. Our Products, Sugarcane Fertilizer. http://www.tcccthai.com/en/our-products/sugarcane-fertilizer Accessed on 26 August 2019.
Magen H, 1996. Potassium chloride in fertigation. Proceedings of 7th International Conference on Water and Irrigation, Tel Aviv, Israel, 13-16 May 1996, 7: 7 pp.
Lucas T F, Isabella J R, Marcelo L G, 2017. Fertirrigation with sugarcane vinasse: foreseeing potential impacts on soil and water resources through vinasse characterization. J Environ. Sci. Heal. A, 52: 1063-1072.
Khongsanun T, 2019. Mitr Phol Sugarcane Research Center Company Limited, Phukhiao, Chaiyaphum, Thailand. Personal communication.